防火卷帘门的安装使用和维修注意事项时间

防火卷帘门通过手动电控的卷帘门，相比起传统的卷帘门来说，减去了繁琐的开锁和拉门过程，十分适合现代人的使用。防火卷帘门安装、使用和维修过程中有许多的注意事项，许多人对此往往知之甚少，本文就将为大家介绍一下这些注意事项，从而供大家有需要的时候做下参考。

Compared with the traditional rolling shutter door, the manual electric control rolling shutter door reduces the cumbersome process of unlocking and sliding the door, which is very suitable for modern people. There are many precautions in the installation, use and maintenance of fire shutter doors, which many people often know little about. This article will introduce these precautions for you for your reference when you need them.

防火卷帘门安装位置的上端应有可靠的防火设施，在卷帘门的卷筒下端做包箱或吊顶时须设置可拆式活动盖板，在电动卷门机一侧下端须预留500×500mm可拆检修孔，以便于维修保养。

Reliable fire prevention facilities shall be provided at the upper end of the installation position of the fire-proof rolling shutter door. When making a box or ceiling at the lower end of the drum of the rolling shutter door, a removable movable cover plate shall be set, and 500 shall be reserved at the lower end of one side of the electric rolling shutter machine × 500mm removable manhole for maintenance.

2、所有电动控制的卷帘门，启闭运行方向须与开关箱指示相同，特别是在新接通电源试车或外来输入电源变换相线时，应先使用手动装置将门帘置于门洞高度1/2的位置，接通电源后试操作卷门启闭，直到与指示相附，方可正常使用，否则损坏限位器，引起卷帘反卷或冲顶等而造成损失。

2. The opening and closing direction of all electrically controlled roller shutter doors must be the same as that indicated by the switch box, especially when the power is newly connected for trial run or the external input power is used to change the phase line, the manual device should first be used to place the door curtain at the position of 1/2 of the door opening height, and then try to operate the opening and closing of the roller shutter after the power is connected, until it is attached with the indication, it can be used normally, otherwise the limiter will be damaged, causing the roller shutter to reverse roll or rush, causing losses.

3、防火卷帘门操作时，操作者必须站在能看到卷门运行状态的位置进行操作，否则易发生意外而受损。

3. When operating the fire shutter door, the operator must stand at the position where the operation state of the shutter door can be seen, otherwise it is easy to be damaged by accident.

4、防火卷帘门门帘和卷门机禁止与酸、碱性物溶液接触，以防腐蚀门帘表面。

4. The fire-proof rolling shutter door curtain and rolling door machine are prohibited from contacting with acid and alkaline solutions to prevent corrosion of the curtain surface.

5、卷门机在运行、滑行、传动等部位应定期检查(少每年2次)，并根据需要及时加油，以保证卷帘门的正常使用。

5. The operation, sliding, transmission and other parts of the rolling door machine should be checked regularly (at least twice a year), and the oil should be added in time as needed to ensure the normal use of the rolling door.

6、防火卷帘门在启闭停止过程中，应具备随位停止之功能，不应有停止而继续下滑现象，如发生下滑距离大于50mm的情况出现，应立即对卷帘门控制电器和卷门机制动器进行仔细检查修理，运行正常为止。维修注意事项7、防火卷帘门门帘和易锈部位，应进行定期防腐、油漆及保养处理，禁止用重物、硬物冲击门面。

6. In the process of opening and closing, the fire shutter door should have the function of follow-up stop, and should not stop and continue to slide. If the sliding distance is greater than 50mm, the shutter door control appliance and the shutter mechanism actuator should be carefully checked and repaired immediately until they operate normally. Maintenance precautions 7. The curtain and rusty parts of the fire-proof rolling shutter door should be regularly treated with anti-corrosion, paint and maintenance. It is forbidden to impact the door surface with heavy objects and hard objects.

8、济南防火卷帘门安装维修认为它运行时如有发生较大抖动或异常声音时应停机检查，排除有碍门帘正常启闭的杂物。

8. Jinan fire shutter door installation and maintenance believes that if there is a large shake or abnormal sound during its operation, it should be shut down for inspection to eliminate the sundries that hinder the normal opening and closing of the curtain.

9、防火卷帘门底梁座上限位置须与轴承架下端保持大于200mm的距离，以确保制动停止时不发生冲顶现象。通过上文的介绍，我们已经大致了解了防火卷帘门安装、使用、维修过程中的注意事项。

9. The upper limit of the bottom beam seat of the fire shutter door must be kept at a distance of more than 200mm from the lower end of the bearing frame to ensure that there is no jacking when the brake stops. Through the above introduction, we have roughly understood the precautions in the installation, use and maintenance of fire shutter doors.

从中我们可以看到，防火卷帘门安装时要注意各个部位的连接紧密，再投入使用前要反复检查，避免使用过程中再出现些什么问题。使用时，大家要注意避免防火卷帘门接触到一些对它有损害的物质，同时，防火卷帘门一定要及时进行保养维护，从而延长它的使用寿命。更多相关内容就来我们网站http://www.jnyuqilin.com咨询吧。

We can see from it that when installing the fire shutter door, we should pay attention to the tight connection of all parts, and check repeatedly before putting it into use to avoid any problems in the process of use. When using, you should pay attention to avoid the fire shutter door from contacting some substances that may damage it. At the same time, the fire shutter door must be maintained in time, so as to prolong its service life. Come to our website for more relevant content http://www.jnyuqilin.com Consult.